Hudson International
Shining the light on maintenance technology for the 21st century.

HUDSON INTERNATIONAL

MATERIAL SAFETY DATA SHEET

 

IDENTITY #: C-771 COIL CLEAN

 

SECTION I

 

Manufactured For:

            Hudson International                                                       Emergency Telephone Number

           

80 Leuning Street
                                                                       1-800-255-3924

            South Hackensack, NJ 07606                                         Telephone for Information

                                                                                                            1-877-482-2436

                                                                                                Date Prepared: May 2007

                                                                                                Prepared By: Staff

 

 

SECTION II – HAZARDOUS INGREDIENTS / IDENTITY INFORMATION

 

Hazardous Components                         OSHA PEL        ACGIH TLV       % OPTIONAL

Sodium Metasilicate                                  2 mg/m3        2 mg/m3             20-40%

CAS # 6834-92-0

Sodium Hydroxide                                     2 mg/m3        2 mg/m3           Prop.

CAS # 1310-73-2

 

 

Hazard Ratings

Health…… 1

Flammability…… 0

Reactivity…… 0

Personal Protection…… B

 

 

SECTION III – PHYSICAL / CHEMICAL CHARACTERISTICS

 

Boiling Point: 212°F                                           Specific Gravity (water = 1): >1

Vapor Pressure (mmHg): N/A                              pH: 9.0

Vapor Density (air = 1): N/A                                Evaporation Rate: N/A

Solubility in Water: Complete                              %  Volatile: N/A

 

Appearance and Odor: White granular powder with no odor

 

 

SECTION IV – FIRE AND EXPLOSION HAZARD

 

Flash Point (method used): None

Flammable Limits:                     LEL: N/A           UEL: N/A

Extinguishing Media: Water fog, foam, Carbon dioxide, or dry chemical

Special Fire-Fighting Precautions: None

Unusual Fire and Explosion Hazards: None

 

 

SECTION V – REACTIVITY DATA

 

Stability:           Unstable [ ]                   Stable [X]

Conditions to Avoid: Extreme heat

Incompatibility (materials to avoid): Moisture, dusting, or acids. Do Not Mix with other chemicals.

Hazardous Decomposition or Byproducts: Sodium oxide

Hazardous Polymerization:         May Occur [ ]                Will Not Occur [X]

Conditions to Avoid: See Above                          

Incompatibility (materials to avoid): See Above

 

 

SECTION VI – HEALTH HAZARD DATA

 

Routes of Entry:        Eyes? YES            Skin? YES        Inhalation? No                Ingestion? YES

Health Hazards (Acute and Chronic): Eyes – may cause conjunctivitis after prolonged exposure

Skin – May cause dermititis or skin burning after prolonged exposure.

Inhalation – no hazard.

Ingestion – May cause irritation of mucous membranes.

 

Carcinogenicity:             NTP? No           iARC? No          OSHA Regulated? No

 

Emergency and First Aid Procedures: Eyes – Immediately flush with running water for at least 15 minutes keeping lids apart. If irritation persists, get medical attention.

Skin – Wash with soap and water. Get medical attention if irritation persists.

Ingestion – DO NOT induce vomiting. If conscious give person large quantities of water and get immediate medical attention.

 

 

SECTION VII – PRECAUTIONS FOR SAFE HANDLING AND USE

 

Steps to be Taken in Case of Spill or Release: Rinse area with water or a diluted, mild acid such as Acetic (Vinegar) or Citric acid. Absorb with floor absorbent, sawdust, or rags.

Waste Disposal Method: Flush down sanitary sewer or place in sealed container and dispose of according to Federal, State and Local authorities.

Precautions Storage and Safe Handling: Do not store at temperature extremes. Keep from freezing. Avoid contact with eyes and skin. Do not take internally.

Other Precautions: Keep out of reach of children.

 

 

SECTION VIII – CONTROL MEASURES

 

Respiratory Protection: None required

Ventilation: Local exhaust adequate

Protective Gloves: Solvent resistant gloves

Eye Protection: Safety glasses, goggles or face shield

Other protective Clothing or Equipment: Eye was should be accesible

Work Hygienic Practices: Wash thoroughly after use. Launder contaminated clothing before reuse.